Product ID:RIFLE BORE CLEANER
MSDS Date:01/01/1987
FSC:6850
NIIN:00-249-8029
MSDS Number: BJKWW

MALTER INTERNATIONAL BULK CHEMICAL DIVISION

80 FIRST STREET
GRETNA, LA 70053
US

Emergency Phone: 504-362-3232

Info Phone: 504-362-3232 OR 800-535-4095

Cage: 27978

MALTER INTERNATIONAL BULK CHEMICAL DIVISION

GRETNA, LA 70053 US

Telephone: 504-362-3232, OR 800-535-4095

Cage: 27978

NAPHTHA, MEDIUM ALIPHATIC

CAS: 64742-88-7

Fraction By Weight: 60%

LIGHT OIL

Fraction By Weight: 35%

CORROSION INHIBITOR

Fraction By Weight: 5%

LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5G.KG ESTIMATED
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ON RARE OCCASIONS, PROLONGED AND
REPEATED EXPOSURE TO OIL MIST POSES A RISK OF PULMONARY DISEASE
SUCH AS CHRONIC LUNG INFLAMMATION. THIS CONDITION IS USUALLY
ASYMPTOMATIC AS A RESULT OF REPEATED SMALL ASPIRATIONS. SHORTNESS
OF BREATH AND COUGH ARE THE MOST COMMON SYMPTOMS. ASPIRATION MAY
LEAD TO CHEMICAL PNEUMONITIS.
Explanation of Carcinogenicity:THE COMPONENTS OF THIS PRODUCT HAVE NOT
SHOWN ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:INHALATION:HEADACHE SEVERE:EDEMA, HEMORRAGE
WHICH MAY BE FATAL. INCREASED RESPIRATION RATE, INCREASED HEART
RATE, AND A BLUISH DISCOLORATION OF THE SKIN. COUGHING, CHOKING,
AND GAGGING DUE TO ASPIRATI ON. GASTROINTESTINAL DISCOMFORT MAY
DEVELOP, FOLLOWED BY VOMITTING. SKIN IRRITATION AND DERMATITIS FROM
OVEREXPOSURE
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
USE CAUTION WHEN HANDLING OR USING THIS PRODUCT.

First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE : IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION:DO NOT INDUCE
VOMITING-GIVE 2-4 OZ OLIVE OR VEGETABLE OIL AND 1-2OZ ACTIVATED
CHARCOAL.

Flash Point Method:TCC
Flash Point:257F,125C
Autoignition Temp:Autoignition Temp Text:UNKNON
Lower Limits:0.7
Upper Limits:5.0
Extinguishing Media:DRY CHEMICAL PREFERRED, FOAM OR WATER CAN ALSO BE
USED, BUT CAN CAUSE EXCESSIVE FROTHING.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.

Spill Release Procedures:CONTAIN SPILL IMMEDIATELY. DO NOT ALLOW SPILL
TO ENTER SEWERS OR WATERCOURSES, REMOVE ALL SOURCES OF IGNITION.
ABSORB WITH APPROPRIATE INERT MATERIAL SUCH AS SAND, CLAY, ETC.
LARGE SPILLS MAY BE PICKE D UP USING VACUUM PUMPS, SHOVELS,
BUCKETS, ETC.

Handling and Storage Precautions:DO NOT TRANSFER TO UNMARKED
CONTAINERS. STORE IN CLOSED CONTAINERS AWAY FROM HEAT, SPARKS, OPEN
FLAME, OR OXIDIZING MATERIALS. COMBUSTIBLE LIQUID.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR
WITH A DUST AND MIST FILTER IF REQUIRED. PROTECTION IS NOT REQUIRED
UNDER NORMAL USE CONDITIONS.
Ventilation:NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF USE.
MECHANICAL EXHAUST RECOMMENDED IF USED IN ENCLOSED AREA.
Protective Gloves:IMPERVIOUS SYNTHETIC RUBBER IF REQUIRED.
Eye Protection:USE CHEMICAL SAFETY GOGGLES AS REQUIRED.
Other Protective Equipment:FOR PROLONGED OR REPEATED EXPOSURES, USE
IMPERVIOUS SYNTHETIC RUBBER CLOTHING (BOOTS, APRONS, ETC.).
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
NONE

HCC:N1
Boiling Pt:B.P. Text:358F,181C
Vapor Pres:NEGLIGIBLE
Vapor Density:4.5 AIR=1
Spec Gravity:0.84
pH:UNKNON
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, PALE LUBRICATING OIL
Percent Volatiles by Volume:UNKNON

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS CHLORINE AND CONCENTRATED OXYGEN.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER TOXIC
BYPRODUCTS OF INCOMPLETE COMBUSTION

Waste Disposal Methods:WASTE MAY BE BURNED IN AN APPROVED INCINERATOR
OR DISPOSED OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND
FEDERAL LAWS AND REGULATIONS. RECYCLE IF POSSIBLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.